軟化水設備，顧名思義即降低水硬度的設備，主要除祛水中的鈣、鎂離子，通俗的說就是降低水的硬度的設備，其作用主要有去除水中的鈣鎂離子、活化水質，殺菌滅藻，防垢除垢。今天春新軟化水設備廠家就介紹一下軟化水設備的維護及停用保養。

一、軟化水設備的維護

①保證輸入的電壓電流穩定。防止受潮和水浸。防止在鹽閥上結生鹽橋

②定期向鹽箱內加固體顆粒食鹽(嚴禁加精鹽或加碘鹽)必需保證鹽箱內食鹽溶液處于過飽和狀態。加鹽時要注意不要將固體顆粒食鹽撒入到鹽井內。堵塞吸鹽管路。由于固體顆粒食鹽中含有一定量的雜質，大量的雜質會沉積在鹽箱底部，堵塞鹽閥，所以要定期清理鹽箱底部的雜質。清洗時可打開鹽箱底部的排污閥，用清水沖洗直至無雜質流出為止，鹽箱的清洗周期應根據固體顆粒食鹽的雜質含量來確定。

③定期檢查射流器及吸鹽管路的氣密性。

④每年要將軟水器拆卸一次。并檢查樹脂的損耗量和交換能力，更換老化嚴重的樹脂，對于鐵中毒的樹脂可用鹽酸溶液進行復蘇。

二、軟化水設備的停用保養

應對離子交換樹脂樹脂進行一次充分再生，軟水器在臨時停用前。將樹脂轉換成鈉型進行濕法保養。夏季停用時(如采暖鍋爐用軟水器，一般夏季要停用數個月)每月應至少對軟水器進行一次沖洗，防止交換罐內滋生微生物而使樹脂發霉，結塊。如果發現樹脂發霉，可進行滅菌處理。一般用1%甲醛溶液浸泡數小時，然后用水沖洗至無甲醛臭味為止。冬季停用應做好防凍措施，防止樹脂內水分因凍結造成樹脂脹裂破碎，可以把樹脂貯存于食鹽水溶液中，食鹽水的濃度要根據氣溫條件進行配制。